Fuse crate diagram (fuse layout), location and also assignment of fuses and also relays Ford traveler / explorer Sport (U152; 2000, 2001, 2002, 2003, 2004, 2005).
You are watching: 2003 ford explorer fuse box location

Checking and also Replacing Fuses
Fuses and circuit breakers defend your vehicle’s electric system native overloading. If electric parts in your vehicle are not working, the system may have actually been overloaded and blown a fuse or tripped a circuit breaker. Prior to you change or repair any type of electrical parts, inspect the proper fuses or circuit breakers.
To check a fuse, look in ~ the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
Before instead of fuses inspect that the crucial has been removed from the ignition and that all the services are switched turn off and/or disengaged.Always disconnect the battery before servicing high current fuses.Always replace a fuse with one that has actually the stated amperage rating. Utilizing a fuse through a higher amperage rating can cause severe cable damage and also could start a fire.Never replace a damaged fuse with anything various other than a brand-new fuse. Use always an undamaged fuse that the very same color.If a fuse blows again contact a qualified business center.Passenger Compartment Fuse Box
The fuse dashboard is located below the instrument panel on the driver’s side.


1 | 30 | Memory seat module, Driver power seat (2003-2005), Driver strength lumbar (2005) |
2 | 20 | Heated seat (2001-2002), Moonroof |
3 | 20 | Radio, Amplifier, power antenna (2001-2002), DVD |
4 | 5 | Front wiper module |
5 | 15 | Flasher relay (Turn, hazards) |
6 | 10 | Right horn (2001-2002), Key-in-chime (2003-2005) |
7 | 15 | Heated mirrors |
8 | 5 | Heated PCV (2004-2005; 4.0L engine only) |
9 | — | Not supplied (spare) |
10 | 10 | Heated backlight relay coil, Heated seat module (2001-2002), Temp blend actuator (2001-2002), A/C clutch contact |
11 | 20 | Heated seats (2003-2005) |
12 | 5 | Foglamp switch (2001-2002), 4x4 module |
13 | 5 | Overdrive release switch, Flex fuel sender (2001-2003) |
14 | 5 | PATS module |
15 | 5 | Rear wiper module, Cluster, TPMS (2001-2003) |
16 | 5 | Power mirror, hands-on climate control, TPMS |
17 | 15 | Delayed acc. Coil, Battery saver, inner lamps (front and also rear), gloves compartment lamp |
18 | 10 | Left horn (2001-2003), flexible fuel pump (2004-2005) |
19 | 10 | RCM, PAD indicator (2001-2002) |
20 | 5 | Memory driver seat switch, Driver seat module, Body protection Module (BSM), PATS LED, Sunload sensor (2001-2003) |
21 | 5 | Instrument cluster, Compass, Flasher coil |
22 | 10 | ABS, IVD Controller |
23 | 15 | 2001-2003:Brake pedal position switch, Driver brake used relay, redundancy cruise deactivate switch |
24 | 15 | Cigar lighter, OBD II, Neutral tow |
25 | 5 | Mode-Temperature actuator for auxiliary climate control, Trailer tow battery charge coil, TPMS (2004-2005) |
26 | 7.5 | Reverse park aid, Brake shift interlock, approach lamp relay coil (2001-2002), IVD switch |
27 | 7.5 | Automatic dimming mirror, Digital transmission variety sensor, back-up lamps |
28 | 5 | Radio (Start)/DVD (Start) |
29 | 10 | Digital transmission range sensor, PWR feeding to fuse #28 (Start feed) |
30 | 5 | Daytime running Lamps (DRL), remote solenoid, DEATC climate controller, hands-on climate control, hands-on climate control temp blend actuator |
These relays are situated on the reverse side that the passenger compartment fuse panel.

1 | Flasher relay |
2 | Rear defrost |
3 | Delayed accessory relay |
4 | Open |
5 | Battery saver |
6 | Open |
7 | Open |
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment.


1 | 60 | PJB |
2 | 30 | BSM |
3 | 20 | GCC pusher pan (2001-2002; violin only) |
4 | 30 | Rear defrost |
5 | 40 | Anti-lock Brake system (ABS) pump |
6 | 60 | Delayed accessory, Power home windows (2004-2005), Audio (2004-2005) |
7 | 20 | Power point #2 |
8 | 30 | 4x4 change motor (2004-2005) |
9 | 20 | Power point #1 |
10 | 30 | ABS module (valves) |
11 | 40 | PTEC (2001-2003), Powertrain control Module (PCM) (2004-2005) |
12 | 50 | Ignition relay/Starter relay |
13 | 40 | Trailer tow battery. Trailer tow turn signals |
14 | 10 | Daytime running Lamps (DRL) (Canada), Foglamps (2001-2002; fiddle only) |
15 | 15 | Memory (KAPWR) (2001-2002), memory (PCM/DEATC/Cluster) (2003-2005), Courtesy lamps (2003-2005) |
16 | 15 | Headlamp move (2001-2003), Foglamp switch (2003), Park lamps (2004-2005), Autolamp parklamps (2004-2005), former foglamps relay coil (2004-2005) |
17 | 20 | 4x4 (v-batt 2) (2001-2003) |
5 | Two-speed 4x4 (relay coils) (2004-2005) | |
18 | 20 | 4x4 (v-batt 1) (2001-2003), PCM with two-speed 4x4 clutch (2004-2005) |
19 | 20 | High beam relay |
20 | 30 | Trailer electric brake module |
21 | 30 | Front wiper motor |
22 | 20 | Autolamp; low beam |
23 | 30 | Ignition switch, PCM diode (2004-2005) |
24 | 20 | Rear fog lamps (2001-2002; export only) |
25 | 15 | Brake on-off (2004-2005) |
26 | 15 | Fuel pump (2001-2003) |
20 | Fuel pump (2004-2005) | |
27 | 20 | Trailer tow lamps, Trailer tow back-up |
28 | 20 | Horn relay |
29 | 60 | PJB |
30 | 20 | Rear wiper motor |
31 | — | Not used |
32 | — | Not used |
33 | 30 | Auxiliary blower motor |
34 | 30 | Power seats, flexible pedals |
35 | 20 | Rear power suggest (2001-2002) |
36 | 40 | Blower motor |
37 | 15 | A/C clutch relay/Transmission |
38 | 15 | Coil top top plug (2001-2003), HEGO (2004-2005), VMV (2004-2005), CMS (2004-2005), ESM (2004-2005), CVS (2004-2005) |
39 | 15 | Injectors/Fuel pump relay |
40 | 15 | PTEC power (2001-2003), PCM strength (2004-2005) |
41 | 15 | HEGO (2001-2003), VMV (2001-2003), CMS (2001-2003), PTEC (2001-2003), Coil ~ above plug (2004-2005; 4.6L engine only), Ignition coil (2004-2005; 4.0L engine only) |
42 | 10 | Right short beam |
43 | 10 | Left low beam |
44 | 15 | Front foglamps |
45 | 5 | Brake press switch (2001-2002) |
2 | Brake push switch (ABS) (2003-2005) | |
46 | 20 | High beams |
62 | 30 | Circuit Breaker: Delayed accessory (2001-2002), Power windows circuit breaker (2003-2005) |
Relay | ||
47 | Horn relay | |
48 | Fuel pump relay | |
49 | High beam relay | |
50 | Fog desk lamp relay | |
51 | Police IVD relay | |
DRL relay (Canada) | ||
52 | A/C clutch relay | |
53 | Trailer tow right turn | |
54 | Trailer tow left turn | |
55 | Blower engine relay | |
56 | Starter relay | |
57 | PTEC relay | |
PCM relay | ||
58 | Ignition relay | |
59 | Driver brake applied or DRL relay (Canada only) | |
Diode | ||
60 | PCM diode | |
61 | A/C clutch diode |
Rear Relay Box
The relay crate is situated on the behind passenger side 4 minutes 1 trim panel.

14 | Not used |
15 | Trailer tow back- increase lamps |
16 | Not used |
17 | Not used |
18 | Not used |
19 | Trailer tow park lamps |
20 | Trailer tow battery charge |
21 | Not used |
22 | Approach lamps |
23 | Not used |
Diode | |
3 | Not used |
4 | Not used |
The relay box is situated on the front best fender fine underneath the speed control module (Canadian vehicles equipped through AdvanceTrac).


This website offers cookies to enhance your experience. We"ll i think you"re ok through this, however you have the right to opt-out if friend wish. Cookie settingsACCEPT
Privacy & cookie Policy
near
Privacy Overview
This website provides cookies to improve your suffer while you navigate v the website. Out of this cookies, the cookie that are categorized as necessary are stored on your internet browser as lock are vital for the functioning of straightforward functionalities of the website. We likewise use third-party cookie that assist us analyze and also understand just how you use this website. These cookies will certainly be save in your web browser only v your consent. You additionally have the option to opt-out of this cookies. But opting the end of some of these cookie may have an impact on your searching experience.
Necessary cookies space absolutely essential for the website to function properly. This group only contains cookies the ensures basic functionalities and security features of the website. These cookies do not save any personal information.
See more: In Baseball How Many Outs In An Inning S In Baseball? How Many Outs You Need To End An Inning
Any cookie that might not be an especially necessary for the website to duty and is used specifically to collect user an individual data via analytics, ads, other embedded materials are termed together non-necessary cookies. That is mandatory to procure user consent before running these cookies on her website.